Scientific and rational fermentation can promote the growth of disease resistant organic compounds during the fermentation process, accompanied by a large number of microorganisms and a series of complex biochemical reactions. Microorganisms produce a large amount of special metabolites during the breeding process, such as hormones, antibiotics, and autoimmune substances, which can promote the rapid growth and development of crops, spread soil diseases, and improve crop disease and stress resistance.

Non fermented organic fertilizer not only lacks the aforementioned advantages, but also carries viruses and bacteria that have become the main source of crop diseases.

Precautions during the use of an organic fertilizer crawler stacker:

1. Ensure ventilation and oxygen supply at the bottom of the fermentation platform

2. The pile height covered by the farmyard manure heap is 0.81.5m, the pile width is 1.5-2.0m, and the length can be determined according to the amount of farmyard manure. The amount of compost is too small, which is not conducive to heating up, fermentation, and complete maturation

3. If the use of farmyard manure is too long or there is too much straw, fresh manure should be added during the fermentation process for adjustment

4. The stacked fertilizer piles should be covered to prevent the farm fertilizers on the air dried surface from not fully fermenting

5. Naturally fermented farmyard manure must be adjusted accordingly before undergoing secondary fermentation

(1) Fermentation with weeds and crop straw (can decompose in about 12-15 days):

Crush or chop weeds and crop straw (usually 35 centimeters long), which can be adjusted using 40% fecal water or biogas residue and slurry; 2% urea (with a nitrogen content of 46%) or an equal proportion of compound fertilizer can also be used for adjustment; Fresh animal manure can also be added in a weight ratio of 3:1-4:1 for adjustment

(2) Fermentation with pure feces (can decompose in about 12-15 days): Crushed (chopped) weeds and crop straw can be added for fermentation, and the moisture content of compost can be adjusted appropriately to about 55% -60%, with a weight ratio of 3:14:1.

(3) Fecal fermentation (can decompose in about 15 days):

After directly expanding the bacterial volume, evenly remove a layer from the outer shell, stir, and directly stack it on the fermentation platform. Repeat this operation. If the moisture content is too high, add an appropriate amount of crushed drying auxiliary material to the shell for adjustment;

The precautions for using organic fertilizer equipment in organic fertilizer fermentation tanks are divided into the following four points:

The components of the new device have not been tested yet and may get stuck. When the operator uses the equipment, he needs to increase the temperature of the equipment.

Firstly, raise the temperature until he manually pulls the motor V-belt until it is free, connect and pull the motor 8-10 times according to the normal working options, and then gradually increase the temperature, which takes about 40-50 minutes. In addition to initial temperature regulation, the organic fertilizer equipment needs to continue heating and replenishing heat after startup.

At the same time, it also needs to be adjusted to different temperatures according to different materials. During normal operation, the machine temperature should remain stable, not high or low. The temperature near the head ventilation hole should be maintained at around 200 degrees. At this temperature, most materials can be processed well. When shutting down, the operator should completely cut off the power supply, use a wrench to remove the parts at the head of the equipment, and wait for separate preheating before use.

The above is the relevant content about the organic fertilizer turning machine that we have. When we use it, we still need to follow the rules to operate it. We hope it can be helpful to everyone!